+86 15516432285

mixed copper oxide and sulphide minerals proc

mixed copper oxide and sulphide minerals proc

Flotation of mixed copper oxide and sulphide minerals

2009-3-1 · The total and acid soluble copper assays of the tail from Test D were 0.19% and 0.16% Cu, respectively. This shows that the residual copper found in the tail was mainly associated with copper oxide minerals. The total copper, sulphide copper and oxide copper recoveries of 95.5%, 98.2% and 89.4%, respectively.

Flotation of mixed copper oxide and sulphide minerals

The copper sulphides present in the blend were bornite and chalcopyrite, while the oxides were malachite and minor azurite. From previous flotation investigations of mixed copper oxide and sulphide minerals using xanthate and hydroxamate collectors it was hard to distinguish the impact of the alkyl hydroxamate collector on sulphide recovery as ...

Flotation of mixed copper oxide and sulphide minerals

Lee et al. (2009) studied flotation of mixed copper oxide and sulphide minerals with xanthate and hydroxamate collectors [25]. This investigation has shown that using n-octyl hydroxamates (AM28 ...

Flotation of mixed oxide sulphide copper-cobalt minerals ...

2019-7-1 · For mixed oxide-sulphide ores, up to 80% of the copper and 60% of the cobalt is recovered in the sulphide concentrate while for the oxide concentrate, only 60% of the copper and 40% of the cobalt are usually recovered (Crundwell et al., 2011). With mixed oxide-sulphide ores, it is accepted practice to concentrate sulphide and oxide minerals in ...

Mixed copper sulfide and oxide - Froth Flotation (Sulphide ...

2021-11-19 · You float sulphides with PAX and them add your Hydroxamate to get oxides (add NaHS if your material responds to the sulfidiser). In a traditional way, sulphide and oxide copper minerals do not recover at the same rate. You typically handle their flotation in a sequential manner: sulphide species #1 followed by oxide minerals.

AN INVESTIGATION OF COPPER RECOVERY FROM A

2010-1-19 · Current copper deposits contain significant amounts of secondary non-sulphide minerals and newly discovered deposits are increasingly complex. As a result, research into the improvement of sulphide-oxide copper ores processing through the use of mixed collector systems has surged.

Mechanochemical sulfidization of a mixed oxide-sulphide ...

2020-3-1 · Mechanochemical sulfidization of a mixed sulfide/oxide copper ore by co-grinding with sulfur and additives including Mg(NO 3) 2 and Fe(NO 3) 3 salts and iron, aluminum and magnesium powders was investigated for the first time. Also, the influence of sulfidization during the wet-milling process was examined on the separation efficiency and recovery of copper in detail.

Synchronous extraction of nickel and copper from a mixed ...

2018-3-10 · When mixed oxide-sulfide nickel ore is treated by the existing process for high-grade nickel sulfide ore, approximately half of the non-ferrous metals including nickel, copper and platinum group metals are lost (Kosyakov et al., 1995), resulting in low recovery of valuable metals and poor economic benefit (Senior and Thomas, 2005).

(PDF) A Review of the Flotation of Copper Minerals

Mixed copper sulphide/oxide ores – these contain varieties of both sulphide and oxide minerals, and are the most compl ex copper - bearing ores from a beneficiation point

Flotation of mixed copper oxide and sulphide minerals

Copper sulphide ores Flotation collectors From previous flotation investigations of mixed copper oxide and sulphide minerals using xanthate and Mineral processing hydroxamate collectors it was hard to distinguish the impact of the alkyl hydroxamate collector on sul- Alkyl hydroxamates phide recovery as the sulphide and oxide minerals occurred ...

Flotation of mixed copper oxide and sulphide minerals

Lee et al. (2009) studied flotation of mixed copper oxide and sulphide minerals with xanthate and hydroxamate collectors [25]. This investigation has shown that using n-octyl hydroxamates (AM28 ...

AN INVESTIGATION OF COPPER RECOVERY FROM A

2010-1-19 · Current copper deposits contain significant amounts of secondary non-sulphide minerals and newly discovered deposits are increasingly complex. As a result, research into the improvement of sulphide-oxide copper ores processing through the use of mixed collector systems has surged.

Mixed copper sulfide and oxide - Froth Flotation (Sulphide ...

2021-11-19 · You float sulphides with PAX and them add your Hydroxamate to get oxides (add NaHS if your material responds to the sulfidiser). In a traditional way, sulphide and oxide copper minerals do not recover at the same rate. You typically handle their flotation in a sequential manner: sulphide species #1 followed by oxide minerals.

Lubembe Sulphide and Oxide Ores - Metorex

2014-6-30 · Lubembe. A scoping study, completed in early 2012, confirmed the potential to mine and process mixed sulphide and oxide ores at Lubembe. The Mineral Resource of 93 million tons at a grade of 1.9% copper will be mined by open pit methods, at a rate of 3.6Mtpa run of mine ore. The copper containing minerals, will first be recovered via the ...

Copper Mining and Processing: Processing Copper Ores ...

2021-11-23 · Copper processing is a complicated process that begins with mining of the ore (less than 1% copper) and ends with sheets of 99.99% pure copper called cathodes, which will ultimately be made into products for everyday use.The most common types of ore, copper oxide and copper sulfide, undergo two different processes, hydrometallurgy and pyrometallurgy, respectively, due to the different ...

(PDF) A Review of the Flotation of Copper Minerals

Mixed copper sulphide/oxide ores – these contain varieties of both sulphide and oxide minerals, and are the most compl ex copper - bearing ores from a beneficiation point of view . The major ...

LEACHING OF LOW-GRADE COPPER ORES: A CASE

2017-6-9 · Oxide copper ore, mixed oxide-sulphide ores and low-grade copper sulphide ore, which, for economic reasons, cannot be enriched by flotation, may be processed by leaching methods. Agents for leaching copper can be acid, base, or salt solutions. Of all

Acid leaching of oxide–sulfide copper ore prior the ...

2015-11-26 · 453 Acid leaching of oxide–sulfide copper ore prior the flotation – A way for an increased metal recovery Miroslav D. Sokić1, Vladan D. Milošević1, Velizar D. Stanković2, Vladislav Lj.Matković1, Branislav R. Marković1 1Institute for Technology of Nuclear and Other Mineral Raw Materials, Belgrade, Serbia 2University of Belgrade, Technical Faculty, Bor, Serbia

Effect of pulp potential on the flotation of a sulfide ...

The results show that the mixed potential of the galena electrode fluctuated with time in a regular pattern in a 0.1 mol/L Fe2(SO4)3 solution of pH 1.66 and in a 0.01 mol/L Fe2(SO4) 3 solution of ...

Flotation of mixed copper oxide and sulphide minerals

Copper sulphide ores Flotation collectors From previous flotation investigations of mixed copper oxide and sulphide minerals using xanthate and Mineral processing hydroxamate collectors it was hard to distinguish the impact of the alkyl hydroxamate collector on sul- Alkyl hydroxamates phide recovery as the sulphide and oxide minerals occurred ...

Mixed copper sulfide and oxide - Froth Flotation (Sulphide ...

2021-11-19 · You float sulphides with PAX and them add your Hydroxamate to get oxides (add NaHS if your material responds to the sulfidiser). In a traditional way, sulphide and oxide copper minerals do not recover at the same rate. You typically handle their flotation in a sequential manner: sulphide species #1 followed by oxide minerals.

Lubembe Sulphide and Oxide Ores - Metorex

2014-6-30 · Lubembe. A scoping study, completed in early 2012, confirmed the potential to mine and process mixed sulphide and oxide ores at Lubembe. The Mineral Resource of 93 million tons at a grade of 1.9% copper will be mined by open pit methods, at a rate of 3.6Mtpa run of mine ore. The copper containing minerals, will first be recovered via the ...

Copper Mining and Processing: Processing Copper Ores ...

2021-11-23 · Copper processing is a complicated process that begins with mining of the ore (less than 1% copper) and ends with sheets of 99.99% pure copper called cathodes, which will ultimately be made into products for everyday use.The most common types of ore, copper oxide and copper sulfide, undergo two different processes, hydrometallurgy and pyrometallurgy, respectively, due to the different ...

(PDF) Acid leaching of oxide-sulfide copper ore prior the ...

Sokić et al. [7] performed acid leaching of copper from a copper oxide-sulphide ore excavated from the copper mine Cerovo, a part of the RTB Bor. These authors reported the leaching degree of ...

Oxide Sulfide Copper Ores Leaching

2018-4-26 · The results of column leaching tests on 3 different mixed oxide/sulfide ores from a Chilean deposit are presented. The 3 samples contained different ratios of oxide copper minerals to chalcocite and chalcopyrite. The results of the column leach tests are interpreted in light of the shrinking core model for coarse particle leaching.

Zaldívar Copper Mine - Northern Chile - Mining

2021-10-27 · The main minerals are chalcocite, brochantite and chrysocolla, and mixed sulphide and oxide copper minerals. Primary sulphides are pyrite, chalcopyrite and molybdenite. To the east of the Portezuelo fault in the main zone ore body where

Extraction of Copper from a Refractory Copper Oxide Ore

The study aimed to extract copper from copper oxide ores in which copper minerals had a complex association and dissemination with gangue minerals in the form of fine grain by catalytic oxidation acid leaching. Based on the research on the properties of the material and lots of experiments, the leaching process was performed. The optimum parameters of leaching process were determined as ...

Technological conditions and kinetics of leaching copper ...

2009-12-1 · Minerals Engineering, 2000, 13(14/15): 1647–1652. Article Google Scholar [5] LEE K, ARCHIBALD D, MCLEAN M A. Flotation of mixed copper oxide and sulphide minerals with xanthate and hydroxamate collectors[J]. Minerals Engineering, 2009, 22(4): 395–401. Article Google Scholar [6]

Effect of pulp potential on the flotation of a sulfide ...

The results show that the mixed potential of the galena electrode fluctuated with time in a regular pattern in a 0.1 mol/L Fe2(SO4)3 solution of pH 1.66 and in a 0.01 mol/L Fe2(SO4) 3 solution of ...