journal for copper slag in concrete

PROPERTIES AND EFFECTS OF COPPER SLAG IN CONCRETE

2016-4-11 · International Journal of Advances in Mechanical and Civil Engineering, ISSN: 2394-2827 Volume-2, Issue-2, April-2015 Properties And Effects Of Copper Slag In Concrete 46 PROPERTIES AND EFFECTS OF COPPER SLAG IN CONCRETE M. V. PATIL Applied Mechanics Department, S.V. National Institute of Technology, Surat, Gujarat

(PDF) USE OF COPPER SLAG IN CONCRETE AND CEMENT

IRJET Journal. Download PDF. Download Full PDF Package. This paper. A short summary of this paper. 37 Full PDFs related to this paper. Read Paper. USE OF COPPER SLAG IN CONCRETE AND CEMENT MORTAR AS REPLACEMENT OF SAND. Download. Related Papers. Effect of Copper Slag As A Fine Aggregate on Properties of Concrete.

USE OF COPPER SLAG IN CONCRETE AND CEMENT

2016-11-7 · copper slag. It was observed that flexural strength at 28 days is higher than design mix (without replacement) for 20% replacement of fine aggregates by copper slag, the flexural strength of concrete increased by 14%. It was found that compressive strength and flexural strength is increased due to high toughness of copper slag. 3.

Use of Copper Slag and Fly Ash in High Strength Concrete

2020-4-1 · with 75% copper slag replacement gave the lowest compressive strength value of approximately 80 MPa, which is almost 4% more than the strength of the control mix. For this concrete containing 50% copper slag, fly ash is introduced in the concrete for better strength.

Recycling copper slag in steel fibre concrete for ...

2020-10-20 · The bond strength of concrete increased with increase in up to 80% copper slag content and for 100% replacement level it decreased. The steel fibre concrete mixture containing 80% copper slag (FCS80) yielded optimum bond strength of 17.61 MPa compared 15.35 MPa of

Replacing River Sand with Granulated Copper Slag in

2016-9-9 · copper slag as partial replacement of aggregate to control the amount of bleeding to less than 5 l/m. 2. Studies by Alnuaimi indicated that replac[2005] e-ment of fine aggregate (sand) by copper slag does not have an adverse effect on the load carrying capacity of the concrete columns. Rojas [2008] had reported that copper slag exhibits

STUDY ON COPPER SLAG AND MICRO SILICA EFFECTS

2017-8-19 · The effective utilization of copper slag in such procedures may lead to reduction in the cost of disposal and leads to less environmental problems. Caijun Shi et al (2008) studied the characteristics of copper slag on the mechanical properties of cement, mortars and concrete and concluded that by the use of copper slag in cement and concrete,

(PDF) USE OF COPPER SLAG - ResearchGate

For this research work, M20 grade concrete was used and tests were conducted for various proportions of copper slag replacement with sand of 0 to 60%, cement of 0 to 20% in concrete.

(PDF) SUSTAINABLE CONSTRUCTION MATERIAL - COPPER

For this research work, M^ grade concrete is used and the test is conducted for various proportions of copper slag replacement of sand by 0%, 25%, 50%, 75% and 100%. View full-text Article

Use of waste copper slag, a sustainable material - Journal ...

2014-5-3 · Physical properties. Copper slag grains have a color of black glassy type and a fineness modulus of 3.5. The hardness is about 7 Moh’s scale. Other typical physical properties are given in Table 2.In order to use copper slag as a mineral admixture, it was necessary to carry out an experimental study associating grinding time, average diameter, and pozzolanic activity assessed in mortars [].

USE OF COPPER SLAG IN CONCRETE AND CEMENT

(PDF) USE OF COPPER SLAG IN CONCRETE AND CEMENT

Studies on use of Copper Slag as Replacement Material for ...

2014-8-20 · This work focuses on the use of copper slag, as a partial replacement of sand for use in cement concrete and building construction. Cement mortar mixtures prepared with fine aggregate made up of different proportions of copper slag and sand were tested for use as masonry mortars and plastering. Three masonry wall panels of dimensions 1 × 1 m were plastered. The studies showed that

Copper slag as fine aggregate for high performance

2014-5-16 · study the potential use of copper slag as fine aggregate on the strength of both normal and high strength concrete. Concrete mixtures were prepared using different proportions of copper slag as partial and full replacement of fine aggregate. The percentage of copper slag added by weight ranged between 10-100% of sand used in concrete.

EXPERIMENTAL STUDY OF CONCRETE WITH COPPER

2019-3-6 · Copper slag belongs to medium alkaline material with pH values 6.6-7.2. 1.4 SCOPE The scope of the work includes the studies on the following aspects of cement mortar and cement concrete. Evaluation of copper slag based on cement mortar in brick masonry construction. The percentage of copper slag used for replacement of

International Journal of ChemTech Research

2016-2-28 · split tension and flexural strength of copper slag concrete. The sand is replaced with copper slag in the volume fractions of 10%, 20%, 30%, 40%, 50%, 60% and 100%. Materials Ultra tech Cement of 53 grade, Coarse aggregate of 12mm, river sand and portable water are used for making concrete. Copper slag is the by-product of Sterlite Industries ...

SID.ir | INVESTIGATION ON USING COPPER SLAG AS PART

2021-11-13 · Self compacting concrete (SCC) is a relatively new phenomenon in materials’ science. It is nearly two-decade-old. This type of concrete, with its special features, provides new possibilities that can be used to overcome problems resulted from the lack of proper density in concrete such as reduction of longevity and durability.

International Journal for Innovative Research in Science ...

title={A Comparative Study on Mechanical Properties of Concrete by using Copper Slag & Granite Powder as Partial Replacement for Fine Aggregate}, author={M Lakshmi Kumar, Manne Venkata Krishna, M L Kumar, G. Kalyan and V. Ravi Kumar}, journal={International Journal for Innovative Research in Science & Technology}, volume={5}, number={1},

Life-Cycle Assessment of High-Strength Concrete Mixtures ...

2019-1-2 · Dynamic compressive strength, flexural strength, and tensile splitting strength of copper slag concrete mixes (adapted from Wu et al. []).Note: fcf, 28 d: average flexural strength, moist-cured at 28 days; fcs, 28 d: average tensile splitting strength, moist-cured at 28 days; fcd1, 90 d: average dynamic compressive strength at a strain rate of ∼100 s −1, at 90 days curing age; fcd2, 90 d ...

The Consequences of Substituting Sand with Used Copper ...

2013-10-23 · Journal of Industrial Ecology. Volume 17, Issue 6. ... Using waste copper slag (CS) as a replacement for sand in concrete mixture is becoming popular in Singapore and around the world. What are the consequences of this material substitution? Will this result in lower environmental impact? This work used attributional and consequential life ...

EXPERIMENTAL STUDY OF CONCRETE WITH COPPER

Copper slag as fine aggregate for high performance

[PDF] Use of copper slag as construction material in ...

2005-12-1 · Copper Slag (CS) is produced as waste from roasting of copper, in which sulphur (as SO 2 ) is eliminated. CS was used as fine aggregate (up to 30%) in the design of bituminous mixes like Bituminous Macadam, Dense Bituminous Macadam. Bituminous Concrete and Semi-Dense Bituminous Concrete. Mechanical properties of mix such as Marshall stability, Indirect Tensile Strength was

Durability Study of Concrete Containing Copper Slag as a ...

2016-7-7 · concrete is more than copper slag concrete except 10% replacement level of copper slag. As compared to conventional concrete copper slag concrete with 20%, 30% and 40% shown less water absorption i.e.0.225, 0.28 and 0.22 respectively. Sl No Replacement of copper slag increased decrees in loss of % Replacement of copper slag

International Journal of ChemTech Research

EXPERIMENTAL STUDY ON CONCRETE USING COPPER

Journal of Emerging Technologies and Innovative Research ( An International Scholarly Open Access Journal, Peer-reviewed, Refereed Journal ) ... many researchers had already found ,copper slag possible to use as a material in concrete In this experiment study copper slag in concrete as replacement material of fine aggregate. When 60ml, 180ml of ...

International Journal for Innovative Research in Science ...

Use of Secondary Slags in Completely Recyclable Concrete ...

Copper slag is interesting as an iron source for the production of such a CRC and can be added to concrete, either as alternative binder or as aggregate. By isothermal calorimetry and compressive strength tests it was found that the addition of copper slag as cement replacement is of minor interest.

The Consequences of Substituting Sand with Used Copper ...

AN EXPERIMENTAL STUDY ON SLAG/FLY ASH-BASED

2016-4-13 · International Journal of Mechanical And Production Engineering, ISSN: 2320-2092, Volume- 3, Issue-8, Aug.-2015 An Experimental Study On Slag/Fly Ash-Based Geopolymer Concrete 13 AN EXPERIMENTAL STUDY ON SLAG/FLY ASH-BASED GEOPOLYMER CONCRETE 1CHIEN-CHUNG CHEN, 2IVAN DIAZ, 3KATHLEEN MENOZZI, 4LUIS MURILLO

journal for copper slag in concrete